replacement of steel sludge with cement in concrete

Home>replacement of steel sludge with cement in concrete>

replacement of steel sludge with cement in concrete

Study of Concrete Involving Use of Waste Paper Sludge Ash as

This research will summarize the behavior of concrete with the waste paper sludge ash by replacement of cement in the range of 5%, 10%, 15% and 20% which may help to reduce the disposal problem of sludge and enhance the properties of concrete. As wastepaper sludge ash contains higher percentage of silicon dioxide SiO 2, it may provide extra strength to concrete. This project will try to study the

Chat Now
  • Published in: IOSR Journal of Engineering · 2013Authors: Sajad Ahmad · M Iqbal Malik · Muzaffar Bashir Wani · Rafiq Ahmad

    THE USE OF SEWAGE SLUDGE ASH (SSA) AS PARTIAL

    replacement of cement in concrete with 5% SSA has shown lower water absorption and increase compressive strength of concrete up to 10% as compared with the control samples. Keywords: sewage sludge, waste management, concrete replacement.

    Chat Now
    Cited by: 2

    Structural Performance of Concrete by Partial Replacement of

    Structural Performance of Concrete by Partial Replacement of Cement with Hypo Sludge (paper waste) Abdullah shahbaz khan1, Ram panth2, Gagan Krishna R.R3, Suresh G. Patil4 1PG student, 2Assistant professor, 3Associate professor, 4Professor, 1 .

    Chat Now

    Effect of Replacement of Opc by Paper Sludge Ppt , Concrete ,

    EFFECT OF REPLACEMENT OF OPC BY PAPER. SLUDGE IN COMPRESSIVE STRENGTH OF CONCRETE By Nitin BharadwajH.R 1RV06CV008 Harinandan. B 1RV06CV009 VijethK.R 1RV06CV036 Kishore.

    Chat Now

    Utilization of Waste Paper Pulp by Partial Replacement of Cement

    concrete with the waste paper pulp by replacement of cement in the range of 5%, 10%, 15% and 20% which may helps to reduce the disposal problem of sludge and

    Chat Now

    Use of Sewage Sludge Ash in replacement Of Stone dust in

    Ash in replacement Of Stone dust in Concrete Pavement” submitted in partial fulfillment for the degree of Bachelor of Engineering in Civil Engineering to Gujarat Technological University , Ahmedabad , is a bonafide record of the project work carried out at VVP

    Chat Now

    (PDF) Granite Sludge Reuse in Mortar and Concrete

    Al-Humaiedeh and Khushefati (2013) [33] observed that the replacement of cement by 10% of granite powder waste has no effect on the compressive strength of concrete, while addition up to 20% of .

    Chat Now

    Recent Trends in Replacement of Natural Sand With Different

    conventional cement concrete of the same grade [5]. 2.2 Granulated Blast Furnace Slag According to the report of the Working Group on Cement Industry for the 12th five year plan, around 10 million tonnes blast furnace slag is currently being generated in the country from iron and steel industry. The compressive strength of cement mortar increases as the replacement level of granulated blast

    Chat Now

    Use of Sewage Sludge Ash in replacement Of Stone dust in Concrete Pavement

    Ash in replacement Of Stone dust in Concrete Pavement” submitted in partial fulfillment for the degree of Bachelor of Engineering in Civil Engineering to Gujarat Technological University , Ahmedabad , is a bonafide record of the project work carried out at VVP

    Chat Now

    (PDF) Granite Sludge Reuse in Mortar and Concrete

    Al-Humaiedeh and Khushefati (2013) [33] observed that the replacement of cement by 10% of granite powder waste has no effect on the compressive strength of concrete, while addition up to 20% of .

    Chat Now

    (PDF) REVIEW ON PARTIAL REPLACEMENT OF CEMENT IN CONCRETE

    The concrete mixes using brick or glass as 10%replacement of cement exhibited enhancement in compressive strength about (6, 4.7 and 2.0)% and (7.2, 5.6 and 2)% at age 7, 28 and 90 days .

    Chat Now

    Mechanical properties and Durability Properties of Concrete with .

    Partial Replacement of Cement by Hypo Sludge Hepzibah A1, 2Ranjith Kumar M G 1,2M.E Student. industries like paper industries, steel industries leaving the waste material into the environmental directly or it can use for landfill. One solution to this crisis lies in recycling waste into useful products to replace the natural/ commercial products which will reduce the economic and environmental problem of waste

    Chat Now

    Partial replacement of cement concrete by waste materials

    Sludge (SS) and corn cob ash (CDA) are used in replacement of cement and reduce the cost of concrete production by making use of locally available materials. 1.1 SAW DUST

    Chat Now

    EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY

    For this, the hypo sludge is used as partial replacement in the concrete as high performance concrete. By utilizing this waste the strength will be increased and also cost reduction in the concrete is achieved. 1.3 OBJECTIVES OF THE PROJECT To investigate the utilization of Hypo Sludge as Supplementary Cementitious Materials (LIM) and influence of these hypo sludge on the Strength on concretes

    Chat Now

    Sludge Use in Concrete as a Replacement of Cement -

    International Journal for Research in Engineering Application & Management (IJREAM) ISSN : 2454-9150 Vol-03, Issue-10, Jan 2018 Sludge Use in Concrete as a Replacement of Cement 1 A. D. Mandlik, 2Prof.

    Chat Now

    Experimental Study on Partial Replacement of Cement by Hyposludge

    (hypo sludge) as partial replacement of cement & it is most essential to develop profitable building materials from hypo sludge. It is directed towards developing low cost concrete and light weight

    Chat Now

    Project on Partial Replacement of Cement with Marble Powder

    (1.2)OBJECTIVES; In this project our main objective is to study the influence of partial replacement of cement with marble powder , and to compare it with the compressive and tensile strength of ordinary M20 concrete.

    Chat Now

    A Study on Partial Replacement of Cement with - ijert.org

    A Study on Partial Replacement of Cement with Metakaolin and Fine Aggregate with Waste Foundry Sand . 1 Dr. B. Krishna Rao . Associate Professor,

    Chat Now

    Experimental investigation of hypo sludge as partial replacement

    30-04-2017 · Techniques Construction Of Tables From Sand And Cement , Beautiful Interior Design Ideas - Duration: 11:00. Amazing Contruction News 1,899,157 views

    Chat Now
    Author: Lokesh Loks

    Replacement of Cement in Concrete

    Replacement of Cement in Concrete 93 2.4 Limestone Limestone is calcareous sedimentary rocks formed at the bottom of lakes and seas with the accumulation of shells, bones and other calcium rich goods.

    Chat Now

    Effect of hypo sludge as partial replacement of cement in concrete

    Effect of hypo sludge as partial replacement of cement in concrete Vinai Kant Singh1 Danish Khan2 1Resident Engineer 2PG Student 1MSV International INC 2Rajiv Gandhi Proudyogiki Vishwavidyalaya, Bhopal Abstract— The hypo sludge is a waste material obtained from paper industry. Since, paper is not recyclable for long time, the disposal of hypo sludge poses potential threat on environment. Hypo

    Chat Now

    Experimental Study on the Properties of Concrete with Replacement

    Partial replacement of Quarry Sludge in cement shows 21.68% increased compressive strength if the cement is replaced with 20% quarry sludge compared to the conventional concrete. There is enhanced improvement in the compressive strength of concrete without any addition of super plasticizers or other admixtures.

    Chat Now

    Performance of mortar and concrete incorporating granite sludge

    30-04-2018 · The main objective of the present study is to determine the feasibility of using granite sludge, produced during the manufacturing processes of ornamental stones, as a cement replacement in mortar and production of concrete blocks by assessing their physical, mechanical and durability performance.

    Chat Now

    EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT

    In order to reduce the content of cement in concrete we are replacing cement with metakaolin, sea wage and sand with quarry dust, M-sand which will improve the strength and

    Chat Now

    EFFECT OF STEEL SLAG AND STEEL SLUDGE ON CONCRETE

    studies have been conducted on steel slag as a replacement for cement in concrete but it is still not sufficient and well established. However, there is no significant research carried out using steel sludge in concrete. This study represents the results of electric arc furnace steel slag and steel sludge for replacing cement materials. Both materials were investigated for their pozzolanic properties, strength,

    Chat Now

    EFFECT OF PARTIAL REPLACEMENT OF CEMENT BY FLY ASH AND LIME SLUDGE

    using fly ash and Lime sludge together as partial replacements of cement in concrete. This research work presents an investigation of compressive strength, split tensile strength and abrasion resistance of concrete by adding Lime sludge and Fly ash as partial replacement

    Chat Now

    Performance of steel slag and steel sludge in concrete -

    The impact of environmental cleansing through inclusion of hazardous wastes in cement related products cannot be overemphasized. This paper presents outcomes of laboratory experiments on the utilizations of electric arc furnace steel slag and steel sludge (by-products from steel making industries) as cement replacements in concrete.

    Chat Now

    Research Paper EXPERIMENTAL INVESTIGATIONS ON PARTIAL REPLACEMENT

    thermal industry waste in concrete production as partial replacement of cement.The use of fly ash in concrete formulations as a supplementary cementatious material was tested as an alternative to traditional concrete.

    Chat Now

    FEASIBILITY STUDY ON PARTIAL REPLACEMENT CEMENT BY RMC SLUDGE IN CONCRETE

    13 FEASIBILITY STUDY ON PARTIAL REPLACEMENT CEMENT BY RMC SLUDGE IN CONCRETE T.Bragadeeswaran1, 2K.P. Saranya1, G.K.Arunvivek 1Department of civil engineering,

    Chat Now

    SLUDGE IN CONCRETE STUDY ON PARTIAL REPLACEMENT OF CEMENT

    The compressive strength results of Waste Water Sludge as replacement of cement are shown in table 10 Table 10: Compressive strength of concrete for cement replaced with waste water sludge 4

    Chat Now

    JIPC - P -105

    replacement for cement in M20 concrete. The ETP sludges selected for this study are those generated The ETP sludges selected for this study are those generated by lime treatment of automobile, engineering and lead battery industry effluents.

    Chat Now
    • Published in: I Control Pollution · 2011Authors: G Shivanath · E Arumugam · V MurugesanAbout: Omics

      EXPERIMENTAL INVESTIGATION ON REPLACEMENT OF CEMENT WITH FLY-ASH, STEEL .

      casted by replacement of cement with steel slag (5-10%), red mud (5-10%) and fly ash (20-30%). After that testing of fresh concrete to determine the workability of concrete. 2.1 TESTING ON FRESH CONCRETE:

      Chat Now

      COMPARATIVE STUDY ON UTILIZATION OF WASTE PAPER SLUDGE

      The mix design of concrete as partial replacement with cement in percentage of 0%, 7% and 10% is given in below procedure. We used the Mix Proportions is 1: 1.45: 3.3 for M 20 grade concrete.

      Chat Now

      EFFECTS ON STRENGTH OF CONCRETE BY PARTIAL REPLACEMENT OF CEMENT

      replacement of cement) in concrete when it is mixed in cement concrete for workability, and strength of concrete using OPC (43 grade). Paper sludge ash is supplementary cementitious material and fly ash is pozzolanic materials that can be utilized to

      Chat Now

      Use of furnace slag and welding slag as replacement for sand in concrete

      The waste material was substituted for replacement of fine aggregates and for the preparation of concrete blocks. In this project, we have followed Indian standard methods and arrived at the mix design for M25 grade concrete. Experimental studies were conducted only on plain cement concrete. The preliminary studies were conducted by mixing the slag with the cement concrete cubes of standard

      Chat Now

      Study of Effect of Lime Sludge and Silica Fume on Strength of Concrete

      and waste material as a partial replacement of cement or admixture fly ash, micro silica, steel slag, lime sludge etc. are the few example of these types of material

      Chat Now

      Flexural Behaviour of Reinforced Concrete Beams with Partial .

      cement with GGBS was studied and it was found that the partial replacement of cement with GGBS improves the strength of the concrete substantially compared to normal concrete[2]. The behavior of concrete with GGBS

      Chat Now